Food transition requires the replacement in human diet of animal-based proteins by alternative sources of proteins including plant-based proteins. This calls for a detailed knowledge of the functional properties of plant-based proteins, including their surface activity. In this framework, we provide here a comparative study of the interfacial properties of two plant proteins, extracted respectively from wheat and sunflower. We combine time- and concentration-dependent measurements of the surface tension and the surface rheology, as measured with a pendant-drop set-up, and of the surface excess concentration, as measured by ellipsometry, of plant protein interfacial films. We demonstrate a time-concentration superposition principle for the surface pressure and surface excess concentration, showing that the kinetics for the building of the interfacial films is essentially governed by the diffusion of the proteins from the bulk to the interface. We find that the rheological and structural properties of the interfacial protein films show markedly different behaviors for the two classes of protein, which is encoded in the structural features of the individual proteins: wheat proteins are more surface active than sunflower proteins, are keen to compress and re-arrange at an air-water interface, whereas sunflower proteins do not. This work provides qualitative and quantitative analysis of the comparative interfacial behavior of flexible and rigid plant proteins extracted respectively from wheat and sunflower, and demonstrates that a combination of several experimental techniques is necessary to obtain insightful information on the interfacial properties of any species.

Understanding the origin of the unique rheological properties of wheat gluten, the protein fraction of wheat grain, is crucial in bread-making processes and has raised questions of scientists for decades. Gluten is a complex mixture of two families of proteins, monomeric gliadins and polymeric glutenins. To better understand the respective role of the different classes of proteins in the supramolecular structure of gluten and its link to the material properties, we investigate here concentrated dispersions of gluten proteins in water with a fixed total protein concentration but variable composition in gliadin and glutenin. Linear viscoelasticity measurements show a gradual increase in the viscosity of the samples as the glutenin mass content increases from 7 to 66%. While the gliadin-rich samples are microphase-separated viscous fluids, homogeneous and transparent pre-gel and gels are obtained with the replacement of gliadin by glutenin. To unravel the flow properties of the gluten samples, we perform shear startup experiments at different shear-rates. In accordance with the linear viscoelastic signature, three classes of behavior are evidenced depending on the protein composition. As samples get depleted in gliadin and enriched in glutenin, distinctive features are measured: (i) viscosity undershoot suggesting droplet elongation for microphase-separated dispersions, (ii) stress overshoot and partial structural relaxation for near-critical pre-gels, and (iii) strain hardening and flow instabilities of gels. We discuss the experimental results by analogy with the behavior of model systems, including viscoelastic emulsions, branched polymer melts, and critical gels, and provide a consistent physical picture of the supramolecular features of the three classes of protein dispersions.

Wheat gluten includes two major proteins classes, gliadin (25–60 kg/mol) and glutenin polymers (100 to > 2,000 kg/mol) each comprising several polypeptides routinely identified by size-exclusion chromatography and electrophoresis. Gluten proteins are rich in glutamine (30%) and contain several repeated sequences, linking them to the wide class of intrinsically disordered protein (IDP). Here we showed that an ethanol/water (EtOH/W, 50/50, v/v) extract of an industrial gluten, comprising 1/3 of glutenin polymers and 2/3 of gliadin, underwent liquid-liquid phase separation (LLPS) below 14 °C, leading to two coexisting phases, respectively rich and poor in protein. As the quenching depth increased, proteins of lower and lower molecular weight joined the rich phase, akin to what would have been obtained for a polydisperse polymer sample. Within the rich phase the mass ratio of glutenin over gliadin decreased from 2.5 to 0.5 as the temperature dropped from 14 °C to −0.8 °C. Concomitantly the concentration in glutenin polymers increased up to 143 ± 6 g/L (at 9 °C) and then stopped to evolve, suggesting that the binodal line intersected the gelation line below this temperature. Applying the Flory-Huggins (FH) lattice model for each gluten protein classes, we demonstrated that their partitioning in the coexisting phases followed a same temperature dependency. However, some gliadin species joined the rich phase above their critical temperature. Here, specific interactions with the glutenin polymers through weak forces were exemplified. The study demonstrated the relevance of the Flory-Huggins (FH) lattice model in predicting phase behavior even when applied to complex protein mixtures.

The binary phase diagram of γ-gliadin, a wheat storage protein, in water was explored thanks to the microevaporator, an original PDMS microfluidic device. This protein, usually qualified as insoluble in aqueous environments, displayed a partial solubility in water. Two liquid phases, a very dilute and a dense phase, were identified after a few hours of accumulation time in the microevaporator. This liquid–liquid phase separation (LLPS) was further characterized through in situ micro-Raman spectroscopy of the dilute and dense protein phases. Micro-Raman spectroscopy showed a specific orientation of phenylalanine residues perpendicular to the PDMS surfaces only for the diluted phase. This orientation was ascribed to the protein adsorption at interfaces, which would act as nuclei for the growth of dense phase in bulk. This study, thanks to the use of both aqueous solvent and a microevaporator, would provide some evidence for a possible physicochemical origin of the gliadin assembly in the endoplasmic reticulum of albumen cells, leading to the formation of dense phases called protein bodies. The microfluidic tool could be used also in food science to probe protein–protein interactions in order to build up phase diagrams

The adsorption of a sunflower protein extract at two air− water and oil−water interfaces is investigated using tensiometry, dilational viscoelasticity, and ellipsometry. For both interfaces, a three step mechanism was evidenced thanks to master curve representations of the data taken at different aging times and protein concentrations. At short times, a diffusion limited adsorption of proteins at interfaces is demonstrated. First, a two-dimensional protein film is formed with a partition of the polypeptide chains in the two phases that depends strongly on the nature of the hydrophobic phase: most of the film is in the aqueous phase at the air−water interface, while it is mostly in the organic phase at the oil−water interface. Then a three-dimensional saturated monolayer of proteins is formed. At short times, adsorption mechanisms are analogous to those found with typical globular proteins, while strong divergences are observed at longer adsorption times. Following the saturation step, a thick layer expands in the aqueous phase and appears associated with the release of large objects in the bulk. The kinetic evolution of this second layer is compatible with a diffusion limited adsorption of the minor population of polymeric complexes with hydrodynamic radius R H ∼ 80 nm, evidenced in equilibrium with hexameric globulins (R H ∼ 6 nm) in solution. These complexes could result from the presence of residual polyphenols in the extract and raise the question of the role of these compounds in the interfacial properties of plant protein extracts.

We investigate the structure of gluten polymer-like gels in a binary mixture of water/ethanol, $50/50$ v/v, a good solvent for gluten proteins. Gluten comprises two main families of proteins, monomeric gliadins and polymer glutenins. In the semi-dilute regime, scattering experiments highlight two classes of behavior, akin to standard polymer solution and polymer gel, depending on the protein composition. We demonstrate that these two classes are encoded in the structural features of the proteins in very dilute solution, and are correlated with the presence of proteins assemblies of typical size tens of nanometers. The assemblies only exist when the protein mixture is sufficiently enriched in glutenins. They are found directly associated to the presence in the gel of domains enriched in non-exchangeable H-bonds and of size comparable to that of the protein assemblies. The domains are probed in neutron scattering experiments thanks to their unique contrast. We show that the sample visco-elasticity is also directly correlated to the quantity of domains enriched in H-bonds, showing the key role of H-bonds in ruling the visco-elasticity of polymer gluten gels.

We investigate the linear viscoelasticity of polymer gels produced by the dispersion of gluten proteins in water:ethanol binary mixtures with various ethanol contents, from pure water to 60% v/v ethanol. We show that the complex viscoelasticity of the gels exhibits a time/solvent composition superposition principle, demonstrating the self-similarity of the gels produced in different binary solvents. All gels can be regarded as near critical gels with characteristic rheological parameters, elastic plateau and characteristic relaxation time, which are related one to another, as a consequence of self-similarity, and span several orders of magnitude when changing the solvent composition. Thanks to calorimetry and neutron scattering experiments, we evidencea co-solvency effect with a better solvation of the complex polymer-like chains of the gluten proteins as the amount of ethanol increases. Overall the gel viscoelasticity can be accounted for by a unique characteristic length characterizing the crosslink density of the supramolecular network, which is solvent composition-dependent. On a molecular level, these findings could be interpreted as a transition of the supramolecular interactions, mainly H-bonds, from intra- to interchains, which would be facilitated by the disruption of hydrophobic interactions by ethanol molecules. This work provides new insight for tailoring the gelation process of complex polymer gels.