Food transition requires the replacement in human diet of animal-based proteins by alternative sources of proteins including plant-based proteins. This calls for a detailed knowledge of the functional properties of plant-based proteins, including their surface activity. In this framework, we provide here a comparative study of the interfacial properties of two plant proteins, extracted respectively from wheat and sunflower. We combine time- and concentration-dependent measurements of the surface tension and the surface rheology, as measured with a pendant-drop set-up, and of the surface excess concentration, as measured by ellipsometry, of plant protein interfacial films. We demonstrate a time-concentration superposition principle for the surface pressure and surface excess concentration, showing that the kinetics for the building of the interfacial films is essentially governed by the diffusion of the proteins from the bulk to the interface. We find that the rheological and structural properties of the interfacial protein films show markedly different behaviors for the two classes of protein, which is encoded in the structural features of the individual proteins: wheat proteins are more surface active than sunflower proteins, are keen to compress and re-arrange at an air-water interface, whereas sunflower proteins do not. This work provides qualitative and quantitative analysis of the comparative interfacial behavior of flexible and rigid plant proteins extracted respectively from wheat and sunflower, and demonstrates that a combination of several experimental techniques is necessary to obtain insightful information on the interfacial properties of any species.

The adsorption of a sunflower protein extract at two air− water and oil−water interfaces is investigated using tensiometry, dilational viscoelasticity, and ellipsometry. For both interfaces, a three step mechanism was evidenced thanks to master curve representations of the data taken at different aging times and protein concentrations. At short times, a diffusion limited adsorption of proteins at interfaces is demonstrated. First, a two-dimensional protein film is formed with a partition of the polypeptide chains in the two phases that depends strongly on the nature of the hydrophobic phase: most of the film is in the aqueous phase at the air−water interface, while it is mostly in the organic phase at the oil−water interface. Then a three-dimensional saturated monolayer of proteins is formed. At short times, adsorption mechanisms are analogous to those found with typical globular proteins, while strong divergences are observed at longer adsorption times. Following the saturation step, a thick layer expands in the aqueous phase and appears associated with the release of large objects in the bulk. The kinetic evolution of this second layer is compatible with a diffusion limited adsorption of the minor population of polymeric complexes with hydrodynamic radius R H ∼ 80 nm, evidenced in equilibrium with hexameric globulins (R H ∼ 6 nm) in solution. These complexes could result from the presence of residual polyphenols in the extract and raise the question of the role of these compounds in the interfacial properties of plant protein extracts.

Hard and soft proteins at fluid interfaces

Les enjeux de santé publique et de développement durable conduisent à intensifier l’utilisation de protéines végétales notamment dans les secteurs de biens de consommation comme l’industrie pharmaceutique,l’agro-alimentaire et les cosmétiques. La levée récente de certains verrous technologique permet aujourd’hui la purification industrielle de protéines végétales issus de tourteaux provenant de la production d’huiles végétales. Ces protéines sont valorisables comme substituts aux graisses saturées dans la structuration d’huiles à destination de la consommation humaine. Le manque de texture d’huiles végétales insaturées peut être compensé par ces protéines jouant le rôle de stabilisants et de gélifiants dans les émulsions. Nous nous intéressons aux propriétés fonctionnelles des protéines de blé, de tournesol et de colza, en volume et aux interfaces. Nous avons montré que des gels de protéines de tournesol avec des élasticités modulables sont obtenus par dénaturation thermique. La dynamique de formation de films protéique aux interfaces fluides a été étudiée en combinant des mesures de tensiométrie, de viscoélasticité dilatationnelle et d’ellipsométrie. Les mesures sur plusieurs ordres de grandeurs en concentrations et en temps mettent en évidence différents régimes de structuration associés à différentes dynamiques d’adsorption pour les trois protéines de blé, de tournesol et de colza étudiées. Nous discutons également le rôle de la flexibilité des protéines dans ces différents régimes de structuration.

Challenges of public health and sustainable development require replacing in food products animal proteins by plant proteins. In this optics, it is crucial to understand the structure and kinetic of formation of a film of plant proteins in order to improve the control of emulsions and foams stabilized by these proteins.In this talk we will present experimental results on the behaviour interfacial properties of wheat gluten, sunflower and rapeseed proteins at liquid interfaces. Thanks to a combination of tensiometry, dilatational rheology and ellipsometry, rational physical pictures of the dynamics of the interfacial properties are achieved, for the various proteins and at both air/water and oil/water interfaces. For gluten proteins, a time-concentration superposition of the data is evidenced whatever the subphase concentration, which reveals that the kinetics of protein adsorption at the interface is dominated by bulk diffusion. We propose a consistent physical picture of the multistep diffusion-controlled irreversible adsorption of the gliadin proteins at an air/water interface, and evidence surface-induced conformational changes of the proteins followed by film gelation [1]. Sunflower and rapeseed proteins by contrast do not reorganize once adsorbed at an interface and display a simpler dynamics of film formation. In addition the failure at high concentration of the time-concentration superposition of the tensiometry and viscoelastic data strongly suggest a surface-induced aggregation process, which we confirm with turbidity measurements. By quantitatively comparing the surface pressure dependence viscoelasticity of the various interfaces, we hightlight the crucial role on the behavior of plant proteins at liquid interfaces of the solvent quality and of the protein softness, that is discussed in regard to the protein structure.

Gliadins are edible wheat storage proteins well known for their surface active properties. In this paper, we present experimental results on the interfacial properties of acidic solutions of gliadin studied over 5 decades of concentrations, from 0.001 to 110 g/L. Dynamic pendant drop tensiometry reveals that the surface pressure  of gliadin solutions builds up in a multistep process. The series of curves of the time evolution of collected at different bulk protein concentrations C can be merged onto a single master curve when  is plotted as a function of t where t is the time elapsed since the formation of the air/water interface and  is a shift parameter that varies with C as a power law with an exponent 2. The existence of such time-concentration superposition, which we evidence for the first time, indicates that the same mechanisms govern the surface tension evolution at all concentrations and are accelerated by an increase of the bulk concentration. The scaling of  with C is consistent with a kinetic of adsorption controlled by the diffusion of the proteins in the bulk. Moreover, we show that the proteins adsorption at the air/water interface is kinetically irreversible. Correlated evolutions of the optical and elastic properties of the interfaces, as probed by ellipsometry and surface dilatational rheology respectively, provide a consistent physical picture of the building up of the protein interfacial layer. A progressive coverage of the interface by the proteins occurs at low . This stage is followed, at higher , by conformational rearrangements of the protein film, which are identified by a strong increase of the dissipative viscoelastic properties of the film concomitantly with a peculiar evolution of its optical profile that we have rationalized. In the last stage, at even higher surface pressure, the adsorption is arrested; the optical profile is not modified while the elasticity of the interfacial layer dramatically increases with the surface pressure, presumably due to the film ageing.

Gliadins are edible wheat storage proteins well known for their surface active properties. In this paper, we present experimental results on the interfacial properties of acidic solutions of gliadin studied over 5 decades of concentrations, from 0.001 to 110 g/L. Dynamic pendant drop tensiometry reveals that the surface pressure  of gliadin solutions builds up in a multistep process. The series of curves of the time evolution of collected at different bulk protein concentrations C can be merged onto a single master curve when  is plotted as a function of t where t is the time elapsed since the formation of the air/water interface and  is a shift parameter that varies with C as a power law with an exponent 2. The existence of such time-concentration superposition, which we evidence for the first time, indicates that the same mechanisms govern the surface tension evolution at all concentrations and are accelerated by an increase of the bulk concentration. The scaling of  with C is consistent with a kinetic of adsorption controlled by the diffusion of the proteins in the bulk. Moreover, we show that the proteins adsorption at the air/water interface is kinetically irreversible. Correlated evolutions of the optical and elastic properties of the interfaces, as probed by ellipsometry and surface dilatational rheology respectively, provide a consistent physical picture of the building up of the protein interfacial layer. A progressive coverage of the interface by the proteins occurs at low . This stage is followed, at higher , by conformational rearrangements of the protein film, which are identified by a strong increase of the dissipative viscoelastic properties of the film concomitantly with a peculiar evolution of its optical profile that we have rationalized. In the last stage, at even higher surface pressure, the adsorption is arrested; the optical profile is not modified while the elasticity of the interfacial layer dramatically increases with the surface pressure, presumably due to the film ageing.